wiring diagrams and wire colors for older stratos and jav boats up till present

[lkhartwl]

OMC Fishing Boat Group D.S.I and Ace Industries color codes

Following, is a color code chart for OMC fresh-water boat accessory electrical manufactured before and after 1992. If the boat you are servicing was built prior to '92, you may have to use the color code chart on the right:


From '92 to the present Models prior to '92
Function Wire color / Stripe color Wire color / Stripe color

Fused + from battery Red Red
Negative from battery Black Black
Accessory + Orange/Black Orange/Black
Horn (signaling dev.) Orange/White Orange/White
Horn sw. + Orange Orange/White
Bow light (Nav) Gray/Black Gray/Black
Stern light (Anc) Gray Gray
Nav/Anc sw. + Orange/Gray Orange/Gray
Instrument lights Blue Blue
Courtesy light Blue or Blue/White Blue/Black
Compartment light Lt. Blue Lt. Blue/White
Court/Compart lt. sw. + Blue/Orange Orange/Blue
Bilge #1 - switched Brown Brown
Bilge #2 - switched Brown/Green Brown/Red
Bilge float sw. + Orange/Green Orange/Red
Bilge helm sw. + Brown/Orange Orange/Brown
Port/Fwd aerator pump Tan Brown/White
Port/Fwd aerator sw. + Tan/Orange Brn/Red/Orn
Port/Fwd aer timer sender Tan/Red N/A
Stbd/Aft aerator pump Brown/White Brown/Black
Stbd/Aft aerator sw. + Orange/Brown Brn/Red/Blk
Stbd/Aft aer timer sender Tan/Purple N/A
Port/Fwd recirc pump Tan/Blue Brown/Blue
Stbd/Aft recirc pump Brown/Yellow Brown/Yellow
Timer + 12V Red/Purple Brown/Orange
Timer pulsed output Brown/Black Tan/Purple
Timer 2 min. select Green Green
Timer 6 min select Yellow Red
Select or timer sw. neg. Yellow/Green Tan
Trim pump down Green/White Green/White
Trim pump up Blue/White Blue/White
Trim sw. + Red/White Red/White
Single fuel tank sender Pink Pink
Port fuel tank sender Pink/White Pink/White
Stbd fuel tank sender Pink/Black Pink/Black

now please quit bothering me ok and Jerry please pin this or delete it as I am getting tired of people who are to lazy to call stratos and ask for the paper they give it out for free in an e-mail


Modified by lkhartwl at 1:38 AM 8/11/2009

[Guvner]

Since my boat is 1988 and I just read "If the boat you are servicing was built prior to '92, you may have to use the color code chart on the right:" does anyone know what the color code on the right side might have been? I just see one list.

I sent an email off to Stratos but don't know if I'll ever get an answer.

Thanks... Gary

[Hi-Tech RedNeck903]

This is a old post that you replied too, look at the beginning date of 1-1-2007
The original person also replied on 4-25-08 that he didn't have copies of the wiring diagram anymore.

I did the same thing before I finally read ALL of the replies on this subject, I'm not puttin' ya down especially since I did the same thing, I'm actually tryin' to help ya'll out, out there.

I did find some info that might help on this particular subject.

If you want to get a copy of a general boat wiring schematic follow the link below & it'll give ya the standard wiring for American boats.

http://www.brokeboats.com/biacolors.html

This should work for most or all boats assembled & set-up in the US.
Boat wiring is just like wiring in your home or tow trailer, it should be the same as the rest (a standard) if it was properly set-up to begin with.

I hope this helps ya'll out.

Good luck & happy boatin'

[Hi-Tech RedNeck903]

This is a old post that you replied too, look at the beginning date of 1-1-2007
The original person also replied on 4-25-08 that he didn't have copies of the wiring diagram anymore.

I did the same thing before I finally read ALL of the replies on this subject, I'm not puttin' ya down especially since I did the same thing, I'm actually tryin' to help ya'll out, out there.

I did find some info that might help on this particular subject.

If you want to get a copy of a general boat wiring schematic follow the link below & it'll give ya the standard wiring for American boats.

http://www.brokeboats.com/biacolors.html

This should work for most or all boats assembled & set-up in the US.
Boat wiring is just like wiring in your home or tow trailer, it should be the same as the rest (a standard) if it was properly set-up to begin with.

I hope this helps ya'll out.

Good luck & happy boatin'

[Hi-Tech RedNeck903]

This is a old post that you replied too, look at the beginning date of 1-1-2007
The original person also replied on 4-25-08 that he didn't have copies of the wiring diagram anymore.

I did the same thing before I finally read ALL of the replies on this subject, I'm not puttin' ya down especially since I did the same thing, I'm actually tryin' to help ya'll out, out there.

I did find some info that might help on this particular subject.

If you want to get a copy of a general boat wiring schematic follow the link below & it'll give ya the standard wiring for American boats.

http://www.brokeboats.com/biacolors.html

This should work for most or all boats assembled & set-up in the US.
Boat wiring is just like wiring in your home or tow trailer, it should be the same as the rest (a standard) if it was properly set-up to begin with.

I hope this helps ya'll out.

Good luck & happy boatin'

[Hi-Tech RedNeck903]

This is a old post that you replied too, look at the beginning date of 1-1-2007
The original person also replied on 4-25-08 that he didn't have copies of the wiring diagram anymore.

I did the same thing before I finally read ALL of the replies on this subject, I'm not puttin' ya down especially since I did the same thing, I'm actually tryin' to help ya'll out, out there.

I did find some info that might help on this particular subject.

If you want to get a copy of a general boat wiring schematic follow the link below & it'll give ya the standard wiring for American boats.

http://www.brokeboats.com/biacolors.html

This should work for most or all boats assembled & set-up in the US.
Boat wiring is just like wiring in your home or tow trailer, it should be the same as the rest (a standard) if it was properly set-up to begin with.

I hope this helps ya'll out.

Good luck & happy boatin'

[Hi-Tech RedNeck903]

This is a old post that you replied too, look at the beginning date of 1-1-2007
The original person also replied on 4-25-08 that he didn't have copies of the wiring diagram anymore.

I did the same thing before I finally read ALL of the replies on this subject, I'm not puttin' ya down especially since I did the same thing, I'm actually tryin' to help ya'll out, out there.

I did find some info that might help on this particular subject.

If you want to get a copy of a general boat wiring schematic follow the link below & it'll give ya the standard wiring for American boats.

http://www.brokeboats.com/biacolors.html

This should work for most or all boats assembled & set-up in the US.
Boat wiring is just like wiring in your home or tow trailer, it should be the same as the rest (a standard) if it was properly set-up to begin with.

I hope this helps ya'll out.

Good luck & happy boatin'

[Guvner]

Here's what Stratos sent. Thanks to Robert Dodd, Customer Service Rep, Stratos/Champion Boats.



Thanks for all of the help...

Gary

[lsumike]

Could u please send me the didrams you have , can't find any , boat caught fire.
Thx mike

[fosterc]

Could you send me a copy of those diagrams to. Thanks cfoster123@bellsouth.net

[tommy_walters80]

97 389 SE. Need any schematic I can get for it. All labels for switches are worn off and I am not sure what is what

[ChampioNman]

The OP has passed on to his great reward.

[bama54]

I have a 1995 285 Pro XL. I need a wiring diagram can someone help me out?

[basskicker24]

Can I get these files emailed to me? I have a 96 201 pro XL thanks
zkclapp@yahoo.com

[Tom G.]

Can I get these files emailed to me? I have a 96 201 pro XL thanks
zkclapp@yahoo.com

Look in the sticky threads at the top of the forum page and you will find them there.

[Clove]

Ok I know this is an old post but I am having some issues with a 1999 jav renegade 18. Is anyone still around that has the diagram color code and layout of harness for this boat.

firefighting_skunk@yahoo.com

[JR19]

If this link does not help then I don't know a solution...There is a lot of information in it if you read through all of it...http://www.bbcboards.net/showthread.php?t=90567