PLEASE DELETE THIS THREAD 9/12/22
PLEASE DELETE THIS THREAD 9/12/22
Last edited by reelman; 09-12-2022 at 05:55 PM.
2018 Z19/200 Optimax 2 stroker 24x3 Fury Ultrex 112
Lowrance HDS 12/9 Lives with 3 in 1 ducers
Probably need to post what motor you have and also probably need to post in the forum associated with you make/model of motor.
On the big engine battery cables make sure the terminals are properly crimped.
Make sure the terminals are clean and the nuts are tight.
Boat has 39 hours. 2022 Mercury 175… while rig is MLF w/0 the poles .. have appt the 8th with dealer …
Last edited by reelman; 09-12-2022 at 05:52 PM.
2018 Z19/200 Optimax 2 stroker 24x3 Fury Ultrex 112
Lowrance HDS 12/9 Lives with 3 in 1 ducers
Also posted initial post under Mercs today
2018 Z19/200 Optimax 2 stroker 24x3 Fury Ultrex 112
Lowrance HDS 12/9 Lives with 3 in 1 ducers
That makes me 80% sure the year old Interstate 31 Marine Crank has gone bad!
If charged for a full day it can now turn engine over enough for one start…then it’s down. It cannot hold the alternator charge even after a 20 mile run like yesterday.
Last edited by reelman; 09-12-2022 at 05:53 PM.
2018 Z19/200 Optimax 2 stroker 24x3 Fury Ultrex 112
Lowrance HDS 12/9 Lives with 3 in 1 ducers
Sounds like you found your problem. The Interstate on mine only lasted 10 months. I went to an AGM of a different brand.
You could charge yours and take it somewhere to get a load test, but it will probably tell you what you already figured.
Those Group 31 Interstate AGM batteries do not seem to be up to the task. I went through two of them in 8 months before switching to an Odyssy. Since then, no problems after 15 months.
CMSGT, USAF, Retired
2021 Nitro Z19, Mercury 200 Pro XS 4 Stroke, SN 2B789775
Ultrex 80/45 24v, Helix 8 G3N SI+. Helix 10 G4N DI+, Helix 3GN DI
Take the battery to auto parts store and have it load tested.
Consensus is crank battery is shot and needs a load test NOW...boat is at dealer behind many others so thanx...
HOWEVER even when engine just did click click click the hy plate and tilt still worked... head scratcher?
Last edited by reelman; 09-08-2022 at 03:47 PM.
2018 Z19/200 Optimax 2 stroker 24x3 Fury Ultrex 112
Lowrance HDS 12/9 Lives with 3 in 1 ducers
Sent: Monday, September 12, 2022 12:58 PM
Subject: my email to dealer just now after the BAD Interstate crank was replaced
I discovered on way home boat carpet is peeling off inside wall corner of rod box on my 2022 Nitro Z18…
I bought a can of spray adhesive and container of carpet glue…
will give to techs Dec 5/6 at 100 hour check to repair.
Have owned 8 Skeeters and nothing like these two failures 1st 9 months ever happened!
Am good for 100 hour annual Dec
Monday the 5th at 10 am or Tuesday the 6th at 10am… put me down for one and let me know.
Will bring parts bought from you today.
Happy Halloween and Thanksgiving!!
========
side note to BBC:...(Am taking boat out fishing about 3 hours or so Tuesday 9/13 to double check new battery
and get some casting in since its been OVER a month since August 12th when battery first failed) Thanx for all helping tips.
2018 Z19/200 Optimax 2 stroker 24x3 Fury Ultrex 112
Lowrance HDS 12/9 Lives with 3 in 1 ducers