mark flywheel every 4 1/4 in counter clockwise from #1 tdc that will be 0 on each cyl , measure back clockwise from each 0 2 5/8 in will be 23 degrees________ timming tape p/n is 8538833 outa stock at MERC
mark flywheel every 4 1/4 in counter clockwise from #1 tdc that will be 0 on each cyl , measure back clockwise from each 0 2 5/8 in will be 23 degrees________ timming tape p/n is 8538833 outa stock at MERC
.................................................. ...the scariest thing in life is the unknown ...................................
Last edited by EuropeanAM; 08-15-2022 at 11:15 AM.
Gary
Growing old is inevitable, growing up is optional.......
S.W. Ohio
Got everything back together and for the most part the boat runs well! But she still doesn't like to idle for very long. so far I have replaced stator, trigger, reeds, intake air temp sensor, TPS, had injectors serviced and flow tested, replaced the plugs, wires and checked spark across the board. All boxes have been removed, timing is set to 23* max and idle timing is 4*. Any suggestions?
seem to rich or to lean as in runs outa fuel/bogs at low end acceleration
.................................................. ...the scariest thing in life is the unknown ...................................
not really, just seems to load up at when idling for too long. I like to troll at 2mph when I fish. after 5-10 mins at this speed it dies. Maybe I need to lean the TPS out a bit.
This is meant with the utmost of respect intended: Your 200 EFI was really not designed to be used as a trolling motor.
Dual Mercury Master Technician- for Mercury Outboards, Mercruiser and Mercury Racing at European Marine in Greenville, SC.
Still consider myself a "Marine Apprentice" after 47 years (learn something new every day).
Mercury Parts, Mercury Outboards, Smartcraft & Accessories, Injector Service, TDR Reeds- BBC Sponsor
Understood....
adjusting TPS and or idle timing can change running quality at low speed , adjust TPS to .200 and try it
.................................................. ...the scariest thing in life is the unknown ...................................
Last edited by EuropeanAM; 08-15-2022 at 11:15 AM.
Dual Mercury Master Technician- for Mercury Outboards, Mercruiser and Mercury Racing at European Marine in Greenville, SC.
Still consider myself a "Marine Apprentice" after 47 years (learn something new every day).
Mercury Parts, Mercury Outboards, Smartcraft & Accessories, Injector Service, TDR Reeds- BBC Sponsor